氣缸主要作用是通過壓縮空氣的開關流向實現伸縮和擺動等動作. (一).公司所用到的氣缸主要有以下幾種類型: 一. 無導向氣缸 1.圓缸 需傳感器安裝支架 2.方缸 3.緊湊型氣缸 2010-6-2 1 二. 有導向氣缸 1.帶滑塊的氣缸: a.DGSL 滑塊 精確度高,封閉式滾珠導向,重復精度高, 兩端采用彈性緩沖,并且不帶金屬擋塊 b.SLF 滑塊 扁平結構帶高精度滾珠導軌和可調端位 c. SLF, SLS, SLT 滑塊 窄型結構帶 高精度滾珠導軌 d. SLT 滑臺 高精度,耐重載的滾珠導軌和可調剛性端位. e. 滑動單元(雙活塞) SPZ 雙活塞桿, 2.帶導桿的氣缸 a 微型導向驅動器 DFC 帶滑動導軌. 直徑 4, 6, 10 mm 行程 5 … 30 mm 輸出力 7,5 … 47 N 2010-6-2 2 b 中型導向驅動器 DFM 導向氣缸,內置導軌 C 高精度導桿氣缸 DFP 導向氣缸,抗扭轉, 雙活塞桿. d 緊湊型氣缸 ADVUL 帶防止活塞轉動的導柱 e 導向驅動單元 SLE 直線驅動單元 可配置 圓缸加配件 3.雙活塞桿的氣缸 DPZ 帶兩根平行的活塞桿,位置感測,終端帶彈性緩 沖環 三.其它氣缸 1.直線擺動夾緊缸 CLR 夾緊系統,具有直線及擺動動作,90 度向右 2010-6-2 3 2.擺動氣缸帶可調液壓緩沖器和能補償間隙的齒輪系統. 擺動角度 0 ... 360 用于搬運和裝配的系統產品. 3.平行氣爪/旋轉氣爪自對中,內抓取或外抓取,182°擺角,位置感測 4.夾緊模塊 2010-6-2 4 5.氣囊式氣缸 6.無桿氣缸 7.膜片式氣缸 8.多位置氣缸 (二)常見的氣缸附件 2010-6-2 5 (三) 氣缸常見故障 . 由于安裝與使用不當氣缸也會產生故障. 故障 原因分析 排除方法 活塞桿安裝偏心 重新安裝調整,使活塞桿不受偏心和橫 外 泄 活塞桿端漏氣 潤滑油供應不足 向負荷. 檢查油霧器是否失靈. 漏 缸筒與缸蓋間漏氣 活塞密封圈磨損 緩沖調節處漏氣 活塞桿軸承配合面有雜質 更換密封圈. 活塞桿有傷痕 清洗除去雜質,安裝更換防塵罩. 更換活塞桿. 內 活塞密封圈損壞 更換密封 泄 潤滑不良 檢查油霧器是否失靈 漏 活塞兩端串氣 活塞被卡住,活塞配合面 重新安裝調整,使活塞桿不受偏心和橫 有缺陷. 向負荷. 雜質擠入密封面 除去雜質,采用凈化壓縮空氣. 潤滑不良 檢查油霧器是否失靈 輸出力不足 活塞或活塞桿卡住 重新安裝調整,消除偏心橫向負荷. 動作不平穩 供氣流量不足 加大連接或管接頭口徑 有冷凝水雜質 注意用凈化干燥壓縮空氣, 防止水凝結. 緩沖密封圈磨損 更換密封圈 緩沖效果不良 調節螺釘損壞 更換調節螺釘 汽缸速度太快 注意緩沖機構是否適合 有偏心橫向負荷 消除偏心橫向負荷 損傷 活塞桿損壞 活塞桿受沖擊負荷 沖擊不能加在活塞桿上 氣缸的速度太快 設置緩沖裝置 缸蓋損壞 緩沖機構不起作用 在外部或回路中設置緩沖機構

SMC氣缸型號：
CHDKGB50-10
CHDKGB50-100
CHDKGB50-15
CHDKGB50-15M
CHDKGB50-20
CHDKGB50-25
CHDKGB50-35
CHDKGB50-40
CHDKGB50-50
CHDKGB50-75
CHDKGB5050MXC62
CHDKGB63-100
CHDKGB63-25
CHDKGB63-30
CHDKGB63-35
CHDKGB63-35M
CHDKGB63-40
CHDKGB63-50
CHDKGB63-75
CHDKGB63-80M
CHDKGB80-100
CHDKGB80-100M
CHDKGB80-15M
CHDKGB80-150
CHDKGB80-25
CHDKGB80-50
CHDKGB80-75
CKZ3T50-90T
CKZT50-A015CB
CKZ3T63-105T
CKZT63-A045CS
CKZ1N50-135LT
CKZ1N50-135RT
CKZ2N50-120RT
CKZ2N50-135RT
CKZ3N50-45DT
CKZ3N50-90DP
CKZ3N63-45DP
CKZ3N63-90DT
CKZ-50A011
CKZN50-135LN
CKZN50-135RN
CKZT40-135T
CKZT40-30T
CKZT40-45T
CKZT40-60T
CKZT40-A015CS
CKZT40-A015LS
CKZT40-A015RS
CKZT40-A045CS
CKZT63-120T
CKZT63-A045CS
CKZT63-A045LS
CKZT63-A045RS
CKZT63TN-120T
CKA80-KRF0027-75Y-P5DWZ
CKA-K75
CKA-Y04
CKA-YA04
CKB40-17-102B
CKB40-18-207A
CKB40-18-207B
CKB-Y04
CKCV32-135B-RH
CKG1A40-100
CKG1A40-100Y
CKG1A40-100YA
CKG1A40-125
CKG1A40-125Y
CKG1A40-125YA
CKG1A40-50
CKG1A40-50Y
CKG1A40-50YA
CKG1A40-50YA-P
CKG1A40-50Y-P
CKG1A40-50YZ
CKG1A40-75Y
CKG1A40-75YA
CKG1A40-75YA-P
CKG1A40-75Y-P
CKG1A40-75Y-P5DWL
CKG1A40-75YZ
CKG1A50-100
CKG1A50-100Y
CKG1A50-100YA
CKG1A50-100YABD-L
CKG1A50-100YA-P
CKG1A50-100YBD-L
CKG1A50-100Y-P
CKG1A50-125-X276A
CKG1A50-125Y
CKG1A50-125YA
CKG1A50-125YABD-L
CKG1A50-125YAD
CKG1A50-125YA-P
CKG1A50-125YBD-L
CKG1A50-125YD
CKG1A50-125Y-P
CKG1A50-150
CKG1A50-150Y
CKG1A50-150YA
CKG1A50-150YABD-L
CKG1A50-150YBD-L
CKG1A50-40YA
CKG1A50-50
CKG1A50-50Y
CKG1A50-50YA
CKG1A50-50YA-X276A
CKG1A50-50YA-X276B
CKG1A50-50YABDL
CKG1A50-50YA-P
CKG1A50-50YBDL
CKG1A50-50Y-P
CKG1A50-50Y-X276A
CKG1A50-50Y-X276B
CKG1A50-75
CKG1A50-75Y
CKG1A50-75YA
CKG1A50-75YABDL
CKG1A50-75YA-P
CKG1A50-75YA-X738
CKG1A50-75YBDL
CKG1A50-75Y-P
CKG1A50-75Y-X1515
CKG1A50-75Y-X738
CKG1A50-75YZ
CKG1A63-100
CKG1A63-100-P
CKG1A63-100Y
CKG1A63-100YA
CKG1A63-100YABD-L
CKG1A63-100YA-P
CKG1A63-100YBD-L
CKG1A63-100Y-P
CKG1A63-125
CKG1A63-125B
CKG1A63-125Y
CKG1A63-125YA
CKG1A63-125YABD-L
CKG1A63-125YAD
CKG1A63-125YA-P
CKG1A63-125YBD-L
CKG1A63-125YD
CKG1A63-125Y-P
CKG1A63-150Y
CKG1A63-150YA
CKG1A63-150YABD-L
CKG1A63-150YA-L
CKG1A63-150YA-P
CKG1A63-150YBD-L
CKG1A63-150Y-L
CKG1A63-150Y-P
CKG1A63-150Z
CKG1A63-200Y
CKG1A63-200Y-P
CKG1A63-30
CKG1A63-300Y-P
CKG1A63-50
CKG1A63-50Y
CKG1A63-50YA
CKG1A63-50YABDL
CKG1A63-50YA-P
CKG1A63-50YBDL
CKG1A63-50Y-P
CKG1A63-75
CKG1A63-75Y
CKG1A63-75YA
CKG1A63-75YABDL
CKG1A63-75YA-P
CKG1A63-75YBDL
CKG1A63-75Y-P
CKG1A63-75Y-P
CKG1A63-KRF0028-125YBDL
CKG1A63-KRF0028-75YBD
CKG1B40-50
CKG1B40-50Y
CKG1B40-50YA
CKG1B50-100
CKG1B50-100I
CKG1B50-100Y
CKG1B50-100YA
CKG1B50-100YA-X276A
CKG1B50-100YAL
CKG1B50-100YL
CKG1B50-100Y-X276A
CKG1B50-125Y
CKG1B50-125YA
CKG1B50-125YAL
CKG1B50-125YL
CKG1B50-150
CKG1B50-150Y
CKG1B50-150YA
CKG1B50-25Y
CKG1B50-25YA
CKG1B50-50
CKG1B50-50-P
CKG1B50-50-X1515
CKG1B50-50Y
CKG1B50-50YA
CKG1B50-75Y
CKG1B50-75YA
CKG1B50-75YA-X276A
CKG1B50-75YAL
CKG1B50-75YL
CKG1B50-75Y-X276A
CKG1B63-100
CKG1B63-100Y
CKG1B63-100YA
CKG1B63-100YA-P
CKG1B63-100YZ
CKG1B63-125
CKG1B63-125I
CKG1B63-125Y
CKG1B63-125YA
CKG1B63-150Y
CKG1B63-150YA
CKG1B63-50
CKG1B63-50Y
CKG1B63-50YA
CKG1B63-50Z
CKG1B63-75
CKG1B63-75Y
CKG1B63-75YA
CKG1P63-150YA-P
CKG1P63-150Y-P
CKG40-R050
CKG40-R075
CKG40-R100
CKGA100-125Y
CKGA100-150YL
CKGA100-150Y-P
CKGA32-100Y-X1046
CKGA32-125Y-X1046
CKGA32-75Y-X1046
CKGA32-B6859-100Y
CKGA32-B6859-125Y
CKGA32-B6859-150Y
CKGA32-B6859-50Y
CKGA32-B6859-75Y
CKGA80-100Y
CKGA80-125Y
CKGA80-150YL
CKGA80-50Y
CKP1A63-100Y
CKP1A63-100YA
CKP1A63-125
CKP1A63-125Y
CKP1A63-125YA
CKP1A63-125YA-P74
CKP1A63-125Y-P74
CKP1A63-150
CKP1A63-150Y-P74-85G-X906
CKP1A63-150Y
CKP1A63-150YA
CKP1A63-200Y
CKP1A63-200YA
CKP1A63-50Y-P74-85G-X1442
CKP1A63-50Y
CKP1A63-50YA
CKP1A63-75Y
CKP1A63-75YA
CKP1A63-75YA-P74
CKP1A63-75Y-P74
CKP1A63-75Y-P74-85G-X404
CKP1A63-B5052-50Y
CKP1A63-S0971-50
CKP1A63-S0971-75
CKP1AM63-200Y
CKPA80-150Y
CKQ40-25-DCH244DH
CKQ40-25-DCH245DH
CKQ40-25-DCH248DH
CKQ40-25-DCH249DH
CKQ40-P6136-25
CKQ40-P6138-25
CKQ40-P6140-25
CKQ40-P6142-25
CKQ40-P9616-25
CKQ40-W0377-25
CKQ40-W0378-25
CKQ40-W3950-25
CKQ40-W3951-25
CKQ50-15-DCJ9682J
CKQ50-DCG2437GA15
CKQ50-DCG2438GA15
CKQ50-DCG5907GL12
CKQ50-DCG5918GCA15
CKQ50-DCG7225G-16
CKQ50-DCG7226G-16
CKQ50-DCG5918GCA15
CKQ50-P5743-30
CKQ50-P7118-30
CKQ50-W3247-15
CKQ50-W3247A15
CKQ50-W3247B15
CKQ50-W8040A15
CKQ50-W8041A15
CKQGDB50-199RALS
CKQN50-25-155WA
CKQN50-25-158WA
CKQSC50-125RC
CKQSF50-125RDS
CHDKGB80150XB11
CHDMB20-Z0860
CHDMB20-200
CHDMB20-25
CHDMB20-40
CHDMB20-75
CHDMB20Z0860155
CHDMB25-50
CHDMB25-75
CHDMB32-100
CHDMB32-80
CHDMB40-250
CHDMB40K
CHDMC20-75
CHDMC32-80
CHDMC40-25
CHDMF20-40
CHDMF25-40
CHDMF32-350
CHDMF32-50
CHDMF32K
CHDMG20-205
CHDMG32-75
CHDML20-400
CHDML25-200
CHDQB100-100
CHDQB100-100D
CHDQB100-25D
CHDQB100-50D
CHDQB100-75D
CHDQB100R184910
CHDQB20-0128624

上海維特銳實業發展有限公司現貨供應日本SMC系列產品，如需詳細了解請點擊：SMC全系列